可靠性试验报告

Reliability test report

Customer客户名称: Our Part No产品名称: JY3F-9S2 Date 日期 : 11-Jul-14 A pilot project 试 验 项 目 Test conditions for 试 验 条 件 Test status 试 验 状 况 Result 结 果 The samples were put into alternating high and low temperature heat box, let the high temperature of □ Cold and hot 105±2 ℃shock after 2 H, immediately by low temperature -30±2 ℃shock 2 H for 1cycle, a total of 2 shock tests of Cycle, mechanicaland electrical performance test . 将样品放入高低温湿热交变箱内,让高温 105±2 ℃冲击 2 H后,立即用低温 -30±2 ℃冲击 2 H为□ 冷热冲击 1cycle,共测试 2 Cycle后,机械及电气性能测试合格 . The sample according to vertical or inclined angle of 45 degrees is clamped on the flame □ Flame retardant tester, blue firecone top contact the lower edge, applied 10s, lift the 15s as a cycle, a total of retardant test 3 cycles. Burner lifting of 10s time,samples with flame combustion time shall not exceed 30s . 将样品按垂直或倾斜45度角夹持在阻燃试验仪上，蓝色火锥顶部接触下部边缘，施加10s,解除15s□ 阻燃试验 为一个周期，共进行3个周期。燃烧器解除10s时间内，样品带火焰自燃时间每次不超过30s . □ Vibration test □ 振动试验 □ Thermal cycle test □ 热循环试验 □ High temperature and high humidity storage test The sample quantity 试样数量: 2 PCS, ■ Pass Number of qualified 合格数量: 2 PCS 合格 Unqualified number 不合格数量: PCS □ Fail Bad description不良描述: 不合格 The sample quantity 试样数量: 2 PCS, ■ Pass Number of qualified 合格数量: 2 PCS 合格 Unqualified number 不合格数量: PCS □ Fail Bad description不良描述: 不合格 The sample quantity 试样数量: 2 PCS, ■ Pass The sample of vibration test in 10Hz and 55Hz/2H/3 directionconditions, test its electrical Number of qualified 合格数量: 2 PCS 合格 parameters without exception,no abnormal appearance . Unqualified number 不合格数量: PCS □ Fail 将样品在10Hz～55Hz/2H/3个方向条件下做振动试验，试验后其电气参数无异常，外观无异常 . Bad description不良描述: 不合格 Put the sample in 105±2 ℃ environment for 2 H, then add 50±2℃degrees Celsius in the The sample quantity 试样数量: 2 PCS, ■ Pass environment of 1 H, and then put into the -30±2℃ environment temperature of 2 H, then add 30±2℃Number of qualified 合格数量: 2 PCS 合格 degrees Celsius in the environment of H I 1 cycles, a total of5 cycles. cycle test of mechanical and Unqualified number 不合格数量: PCS electrical performancetest. □ Fail Bad description不良描述: 将样品放入 105±2 ℃的环境中2 H，再放入50±2 ℃的环境中1 H，然后放入 -30±2 ℃的环境中 2 H，不合格 再放入 30±2 ℃的环境中1 H为I cycles,共循环试验 5 cycles. 机械及电气性能测试合格. Must be free from any abnormality in both the construction and characteristics after the relay is lift in a humidity of 90% to 95% RH for48h and then in room temperature and humidity for 2h. Insulation resistance however must be 50MΩ . 将样品放入: 40±2℃相对温度 90~95%RH 中放置 48 H，恢复常温 2 H后，继电器的结构及性能无异常。且绝缘电阻应不小于 50MΩ . The sample quantity 试样数量: 2 PCS, ■ Pass Number of qualified 合格数量: 2 PCS 合格 Unqualified number 不合格数量: PCS □ Fail Bad description不良描述: 不合格 □ 高温高湿储存试验 □ High temperature storage test □ 高温储存试验 The sample quantity 试样数量: 2 PCS, ■ Pass Must be free from any abnormality in both the construction and characteristics after the relay is lift in a Number of qualified 合格数量: 2 PCS 合格 temperature of 105±2℃ for 2h and then in room temperature and humidity for 2h . Unqualified number 不合格数量: PCS □ Fail 将样品放入: 105±2 ℃的恒温箱中储存: 2 H, 恢复常温 2 小时后机械及电气性能测试合格 . Bad description不良描述: 不合格 Page 1 of 2

□ Low temperature storage test □ 低温储存试验 □ Glow-wire test □ 灼热丝试验 备 注 The sample quantity 试样数量: 2 PCS, ■ Pass Must be free from any abnormality in both the construction and characteristics after the relay is lift Number of qualified 合格数量: 2 PCS 合格 in a temperature of -30±2℃ for 2h and then in room temperature and humidity for 2h . Unqualified number 不合格数量: PCS □ Fail 将样品放入: -30±2 ℃的恒温箱中储存: 2 H, 恢复常温 2 小时后机械及电气性能测试合格 . Bad description不良描述: 不合格 In the sample of the environment temperature 15 to 35 DHS DHS C C, humidity 45% to 75% of the The sample quantity 试样数量: 2 PCS, ■ Pass flammable test room within 24 h, after 30 s burning time test, the sample combustion duration less than Number of qualified 合格数量: 2 PCS 合格 2 s, dripping content not thin cotton paper. Unqualified number 不合格数量: PCS □ Fail 将样品在环境温度15 ºC到35 ºC，湿度45%到75%的易燃试验房间内放置24h, 试验中30s灼热时Bad description不良描述: 不合格 间后,样品持续燃烧时间不超过2s,滴落物不引燃薄棉纸. Double-layer thickness: 0.15 + / - 0.02 mm 动簧片厚度: 0.15±0.02 mm B-180 Tested by 测试:: 朱定锁 Checked by 审核: 吴婉珍 Approved by 批准:

Page 2 of 2